![]() ![]() with a governor cart and Quarterly or every 150 hours with an un-governed cart. I think that is way to long to go between changes. Manual said oil changes are recommended 2 years or 300 hours. You have now just completed an oil and filter change on your cart. You should have it between the FULL & FILL mark. Now start the cart up and run at medium rpms for 30 seconds to fill the filter with oil and check for leaks. The plug can be found directly in front of the engine all the way at the bottom shown here in this picture.Ĩ:When you have almost all the oil in, take your cart off the ramps or jack stands, put your tranny in neutral and put your cart in MAINTENANCE MODE(the yellow knob on the back of the F&R lever, pull out and turn 1/4 turn till it drops back in place)this allows the cart to be started in neutral. Safty first.ģ: With your cart secure, put your drain pan under your cart and grab your 14mm shallow well socket or wrench and remove the drain plug to start the oil draining. Be sure to use jack stands to secure your cart. Or use a floor jack and a block of wood to jack up the rear. This will tilt the drain plug lower than the back of the engine. ![]() So the first thing to do is:ġ: Take your cart for a drive to warm up the engine oil so it is easier to drain.Ģ: Whether you are lifter or not, back your cart up onto a set of ramps. ![]() Since a lot of people are now lifting their car, it tends to tilt the engine cradle in such a way that it is hard to drain all the oil out. This should work with both a lifted cart and a non lifted cart. ENGINE OIL AND FILTER CHANGEįirst, lets start with the basic oil & filter change. This post is about how to service your gas Club Car DS gas models 1992-2005 with the FE290cc engine and most FE350cc models. ![]()
0 Comments
Leave a Reply. |
AuthorWrite something about yourself. No need to be fancy, just an overview. ArchivesCategories |